Home > Battery Knowledge > Content

12v Battery Maintenance Aspects

May 18, 2017

12V battery connection. Many people think that 12v battery is a very simple thing, usually do not pay attention to for maintenance, in fact, the daily use of the car, the battery is also considered one of the most important parts, sloppy. Zhou Yongjian said that the battery has a start battery and traction battery points, and start the battery and maintenance-free batteries and "add water" battery. In terms of cars, commonly used to start the battery, because it can make the car energy storage, and then instantly release, so that with a good quality to start the battery, the car is also more rapid start.

Brand batteries more secure.

12v battery on the use and maintenance of the need to pay attention to some of the problems:

1. Battery for a long time do not, it will slowly discharge their own, until the scrapped. Therefore, every time a certain time should start a car, 12V Standard Battery to the battery charge. Another way is to remove the two electrodes on the battery, it should be noted that from the electrode column is unplugged positive and negative two electrode lines, first unplug the negative line, or remove the negative and the car chassis connection. And then unplug the other end with a positive mark (+), the battery has a certain life, to a certain period of time to be replaced. In the replacement of the same order to follow the above, but in the electrode line connected, the order is the opposite, then the first positive, and then then negative.

2. 12V Standard Battery When the ammeter pointer shows the lack of electricity, it is necessary to charge in time. The battery capacity can be reflected in the dashboard. Sometimes in the road to find the power is not enough, the engine can not turn off the fire, as a temporary measure, you can help the other vehicles, with their vehicles on the battery to launch the vehicle, the two batteries connected to the negative and negative, positive and positive The

3. The density of the electrolyte should be in accordance with the different regions, different seasons in accordance with the standard corresponding adjustments.

4. In the loss of electrolyte should be added to the distilled water or special rehydration. Avoid drinking pure water instead. Because pure water contains a variety of trace elements, the battery will cause adverse effects.

5. When starting the car, uninterrupted use of the start-up opportunity causes the battery to be damaged due to excessive discharge. The correct way to use is to start the car every time the total length of not more than 5 seconds, start the interval again less than 15 seconds. 12V Standard Battery In the case of a number of start still not in the case of the circuit, ignition coil or oil and other reasons to find the reasons.

6. Routine traffic should always check the battery cover on the hole is ventilated. If the battery cover hole is blocked, the resulting hydrogen and oxygen row does not go out, the electrolyte expansion, the battery shell will break, affecting the battery life.

7. Check the battery for positive and negative signs of oxidation. You can use hot water often pour the battery wire connection, and clean with copper brush, and coated with butter.

8. Check the circuit where there is no aging or short circuit. 12V Standard Battery To prevent the battery because of excessive discharge and early retirement.

9. Battery prohibited loss of power storage, if used up a few days after the re-charge, easy to appear sulfate plate, capacity decline.

10. Periodic inspection: regularly measure the voltage of a single cell, if one of the battery voltage is lower than 10.5v, then look for repair station repair or repair, so as not to damage the other two good batteries.

11. Electric bicycle design load of 75kg, to avoid with heavy objects, in the start and uphill please use the pedal power.

12. winter battery capacity decreases with the temperature drop This is a normal phenomenon to 20 ℃ as the standard, generally -10 ℃ when the capacity of 80%.

13. Keep the battery surface clean for a long time, when the vehicle is prohibited from exposure, the vehicle should be parked in a cool, ventilated and dry place.

14. Batteries need to be placed for a long time must be fully charged, usually once every month.

15. Vehicles in the start, uphill, overload, 12V Standard Battery the wind with a pedal to help, so as not to discharge large current.

16. Use a special charger when charging, placed in a cool and ventilated place, to avoid high temperature and humidity.

17. Do not use organic solvents to clean the battery case.

18. Do not short-circuit the positive and negative terminals of the battery to avoid danger.

19. prohibit over discharge: When the instrument panel red undervoltage indicator light, indicating that electricity into the hungry area, should be charged.

20. prohibit overcharge: 12V Standard Battery charging time should be based on the length of the distance varies, the longer the mileage, charging time is long, and vice versa is short.

21. If the battery pack fails, please send it to the manufacturer authorized office or the relevant authorities to properly handle. Please do not arbitrarily discard to avoid environmental pollution.